TOUCH CRASH (the blue screen): app_on_touch ran a blocking WebSocket
send (up to 5s) directly in the LVGL touch callback, stalling the
MIPI-DSI flush into a garbage/blue frame + task-watchdog reboot on
every tap. Now touch_cb only gives a semaphore; a dedicated app_task
does the blocking sends, audio, and face changes off the render
thread. WS send timeout cut 5s to 1.5s as belt-and-braces.
RAIN = REACHABILITY (user request): rain now falls only while the
gateway WebSocket is live (gated on gw_connected in rain_tick). It
drains gracefully on disconnect, resumes on reconnect, a genuine
glanceable reachable signal. Idle density bumped 2 to 4 so
connected-idle reads distinctly from disconnected-black.
CALM THE WEDGE CHURN (user request): transient wifi/WS drops no longer
slam to the x_x error face or a CONNECTING banner. Boot goes straight
to the calm idle face (dry until connected). Only a sustained 30s+
outage escalates to x_x (clock_cb); the ~15s wedge-recovery just shows
a brief rain pause.
Two fixes from adversarial concurrency review before flashing:
- persistent single capture task (was xTaskCreate per utterance; a
rapid re-tap or WS-stop-vs-app-start race could put two readers on
one mic/I2S handle and corrupt the codec)
- reset s_talking on disconnect (app_on_disconnect) so the first tap
after a mid-utterance drop starts fresh, not the stop branch
Co-Authored-By: Claude Fable 5 <noreply@anthropic.com>
Night-watch caught a 21s wedge (vs 5-13min baseline) landing exactly
on the boot ping-diagnosis + wifi-stats-dump burst, which hammered the
freshly-recovered SDIO link on every reboot. That scaffolding proved
connectivity long ago; removing it makes each recovery light and clean.
ping_target/ping_diag_task kept as no-op symbols for manual use.
Co-Authored-By: Claude Fable 5 <noreply@anthropic.com>
The wedge metronome (~300s: 297/297/322/437s across bus widths,
clocks, and power modes) matches FRITZ DHCP T1 renewal at half of a
10-min lease. Every wedging build ran an active dhcp client. Static
addressing removes the renewal TX path entirely; if the metronome
dies, root cause #2 is the DHCP renew packet through hosted's write
path. (2.9.7 experiment abandoned: slave image bootloops/rolls back
on this C6; version matrix documented for upstream.)
Co-Authored-By: Claude Fable 5 <noreply@anthropic.com>
1-bit bus alone did not stop the sdio_write timeout wedge (recurred
at ~5min uptime). Modem power save is the new prime suspect: the C6
napping mid-SDIO-transaction matches the minutes-scale periodicity.
Always-powered appliance -> PS_NONE costs ~50mW and removes the
entire failure class if correct. SDIO clock also halved to 10MHz.
Co-Authored-By: Claude Fable 5 <noreply@anthropic.com>
Root cause of the dead data path (assoc/scan/RPC fine, zero data
frames): esp-hosted 1.4.x is formally incompatible with IDF 5.5
(esp-hosted-mcu#47) and the factory C6 slave firmware was ancient
(couldn't even answer a version RPC). Waveshare's examples pin 1.4.* —
do not follow them.
Fix:
- host: espressif/esp_hosted ^2.12 (+ esp_wifi_remote 1.6)
- slave: 2.12.11 network_adapter.bin embedded in the app (c6_ota.c
streams it to the C6 over the SDIO RPC channel at boot when the
reported version is < 2.x; ~10s, no wires, idempotent)
- RAM diet for hosted 2.x's footprint (MEMPOOL_PREFER_SPIRAM,
reduced WIFI_RMT buffers) — without it internal SRAM famine
boot-loops in xTaskCreateStaticPinnedToCore before app_main
- conservative 20MHz SDIO clock for first verified data path
Verified on hardware: DHCP lease (even that healed), 8/8 pings to
router and tower-of-joy at 1-5ms, WebSocket to the gateway connected,
device registered at /devices as desklock-p4 with fw version.
Also: wifi_diag.c L1 SoftAP diagnostic mode (DESKLOCK-DIAG) with
review fixes, boot ping ladder in net.c, static-IP fallback,
face_status() line, docs for the whole failure taxonomy.
Co-Authored-By: Claude Fable 5 <noreply@anthropic.com>
- gateway: GET /devices registry (per-IP connect count, timestamps,
device/fw from new 'hello' protocol event); graceful utterance
errors -> error event; uvicorn ws-ping-timeout 120s
- firmware: hello on WS connect; static 192.168.86.53 fallback after
15s without DHCP; scan-on-boot removed (kept for diagnostics);
ping_interval 8s; fonts regenerated --no-compress (compressed
glyphs render blank with LV_USE_FONT_COMPRESSED off); 8MB factory
partition; montserrat_28; LVGL lock timeout semantics fixed
- docs: sauron endpoint plan, power ladder, versioning policy
Known issue: 'Outside' AP association succeeds but no L2 traffic
flows (no DHCP, no ARP) — worked once at 22:05 then never again;
ToJ side verified clean. Investigation ongoing.
Co-Authored-By: Claude Fable 5 <noreply@anthropic.com>
The device now runs the complete face contract on glass: seven states
with glyph expressions (custom 140px face font), matrix rain as pooled
label streams (22px DejaVu+Noto katakana font), rage kaomoji frames
(64px), orbit arc + elapsed counter wait cues, blink/talk/thought
animations, idle clock (SNTP, Europe/Amsterdam), and the power ladder
(active/ambient 35%/dormant 5% with rain parked).
Voice path: ES7210 mic capture task streams 16k PCM over
esp_websocket_client to the gateway; reply PCM buffers to PSRAM and
plays via the audio task; touch-to-talk (tap to speak, tap to send).
Protocol mapping per docs: thinking->effort, audio->speaking,
error event->rage (auto-composes after 2 loops), WS loss->error face.
Bring-up fixes: 8MB factory partition (fonts overflowed 1.5M),
bsp_display_lock(0) is try-lock in this adapter (use UINT32_MAX),
gong synth yields to feed IDLE0, wifi scan diagnostics (found SSID
case mismatch), esp_websocket_client pinned ~1.3 (1.4 needs IDF>5.5).
Verified on hardware: boots, connects to Wi-Fi and holds an open
WebSocket to the gateway. Sauron (iMac TTY endpoint + ops console)
planned in architecture.md.
Co-Authored-By: Claude Fable 5 <noreply@anthropic.com>
jpmschweitzerandClaude Fable 5